Current through Register Vol. 54, No. 45, November 9, 2024
Section 145.113 - Standard requirements(a) The owner or operator of a unit subject to this subchapter shall calculate the difference between the unit's actual emissions from May 1 through September 30 and the allowable emissions for that period by the following dates: (1) For a unit described in § 145.111(a) (relating to applicability), by October 31, 2005, and each year thereafter.(2) For a unit described in § 145.111(b), by October 31 of the calendar year following the year that this subchapter becomes applicable to the unit and each year thereafter.(b) The owner or operator shall calculate allowable emissions by multiplying the unit's cumulative hours of operation for the period by the unit's horsepower rating and the unit's applicable emission rate set forth in paragraph (1), (2) or (3). (1) The emission rate for a rich burn stationary internal combustion engine with an engine rating equal to or greater than 2,400 brake horsepower shall be 1.5 grams per brake horsepower-hour.(2) The emission rate for a lean burn stationary internal combustion engine with an engine rating equal to or greater than 2,400 brake horsepower shall be 3.0 grams per brake horsepower-hour.(3) The emission rate for a diesel stationary internal combustion engine with an engine rating equal to or greater than 3,000 brake horsepower, or a dual-fuel stationary internal combustion engine with an engine rating equal to or greater than 4,400 brake horsepower shall be 2.3 grams per brake horsepower-hour.(c) The owner or operator shall determine actual emissions by using one of the following:(1) If the owner or operator of the unit is required to monitor NOx emissions with a CEMS operated and maintained in accordance with a permit or State or Federal regulation, data reported to the Department to comply with the monitoring and reporting requirements of this article. Any data invalidated under Chapter 139 (relating to sampling and testing) shall be substituted with data calculated using the potential emission rate for the unit or, if approved by the Department in writing, an alternative amount of emissions that is more representative of actual emissions that occurred during the period of invalid data.(2) If the owner or operator of the unit is not required to monitor NOx emissions with a CEMS, one of the following shall be used to determine actual emissions of NOx:(i) CEMS data, if the owner or operator elects to monitor NOx emissions with a CEMS. The owner or operator shall monitor emissions and report the data from the CEMS in accordance with Chapter 139 or Chapter 145 (relating to interstate pollution transport reduction). Any data invalidated under Chapter 139 shall be substituted with data calculated using the potential emission rate for the unit or, if approved by the Department in writing, an alternative amount of emissions that is more representative of actual emissions that occurred during the period of invalid data.(ii) An alternate calculation and recordkeeping procedure based upon emissions testing and correlations with operating parameters. The operator of the unit shall demonstrate that the alternate procedure does not underestimate actual emissions throughout the allowable range of operating conditions. The alternate calculation and recordkeeping procedures must be approved by the Department, in writing, prior to implementation.(iii) The average emission rate calculated from test data from NOx emission tests conducted from May 1 through September 30 of that year. The emissions tests must be conducted in accordance with the permit emission limit compliance monitoring procedures. Tests must be conducted at least once every 735 hours of operation. The Department may reduce the frequency of the emission testing for a unit based on the consistency of the data gathered from the testing. At least one test is required during the period of May 1 through September 30.(d) The owner or operator of a unit subject to this section shall surrender to the Department one CAIR NOx allowance and one CAIR NOx Ozone Season allowance, as defined in 40 CFR 96.102 and 96.302 (relating to definitions), for each ton of NOx by which the combined actual emissions exceed the allowable emissions of the units subject to this section at a facility from May 1 through September 30. The surrendered allowances shall be of current year vintage. For the purposes of determining the amount of allowances to surrender, any remaining fraction of a ton equal to or greater than 0.50 ton is deemed to equal 1 ton and any fraction of a ton less than 0.50 ton is deemed to equal zero tons.(e) If the combined allowable emissions from units subject to this subchapter at a facility from May 1 through September 30 exceed the combined actual emissions from units subject to this subchapter at the facility during the same period, the owner or operator may deduct the difference or any portion of it from the amount of actual emissions from units subject to this subchapter at the owner or operator's other facilities located in this Commonwealth for that same period.(f) By November 1 of each year, an owner or operator of a unit subject to this subchapter shall surrender the required NOx allowances to the Department's designated NOx allowance tracking system account, as defined in § 121.1 (relating to definitions), and shall provide in writing to the Department the following: (1) The serial number of each NOx allowance surrendered.(2) The calculations used to determine the quantity of NOx allowances required to be surrendered.(g) If an owner or operator fails to comply with subsection (f), the owner or operator shall by December 31 surrender three NOx allowances of the current or later year vintage for each NOx allowance that was required to be surrendered by November 1.(h) The surrender of NOx allowances under subsection (g) does not affect the liability of the owner or operator of units for any fine, penalty or assessment, or other obligation to comply with any other remedy for the same violation, under the CAA or the act. (1) For purposes of determining the number of days of violation, if a facility has excess emissions for the period May 1 through September 30, each day in that period (153 days) constitutes a day in violation unless the owner or operator of the unit demonstrates that a lesser number of days should be considered.(2) Each ton of excess emissions is a separate violation.The provisions of this §145.113 amended April 11, 2008, effective 4/12/2008, 38 Pa.B. 1705.The provisions of this §145.113 amended under section 5 of the Air Pollution Control Act (35 P.S. § 4005).
This section cited in 25 Pa. Code § 129.97 (relating to presumptive RACT requirements, RACT emission limitations and petition for alternative compliance schedule); and 25 Pa. Code § 129.112 (relating to presumptive RACT requirements, RACT emission limitations and petition for alternative compliance schedule).