Opinion
No. 83-596
Decided July 3, 1985.
Workers' compensation — Two-stage press — Allegation of violation of specific safety requirement — Press operated by person other than operator — Rehearing ordered, when.
APPEAL from the Court of Appeals for Franklin County.
On May 18, 1977, claimant, Betty L. Anderson, was injured on the job while working for appellant, Gentzler Tool Die Corporation. Claimant operated a two-stage punch press equipped with safety guards which prevented the operator's hands from entering the "danger zone" while the press was activated. Only one person operated the machine during normal use.
Immediately prior to the injury, claimant's press had been malfunctioning. Claimant asked a co-worker for help to correct the problem. Claimant rehooked her safety guards and began operating the press slowly so that her co-worker could identify and correct the problem. At one point claimant ceased operation of the press and reached into the "danger zone" to adjust a poorly positioned part. Claimant averred that she had no reason to fear that she was in danger because she knew the press would not be activated until she hit her foot pedal. Without claimant's knowledge, at the moment her hand was in the "danger zone," her co-worker manually activated the press. Because the press had been manually activated, the guard did not operate to remove claimant's hand from the danger area. As a result, claimant's right hand was severely injured.
Claimant filed for and received workers' compensation benefits as a result of the injury to her hand. On May 10, 1979, claimant filed an application with the Industrial Commission, appellee, for an additional award based on appellant's alleged violation of the specific safety requirement set forth in IC-5-08.03. After a hearing before a staff hearing officer, appellee granted claimant an additional award in an order stating:
"* * * [C]laimant's injury was the result of employer's failure to provide sufficient guards for the two-phase process during the entire operating cycle of the machine, as required by IC-5-08.03(A) * * *." (Emphasis sic.)
Appellant requested a rehearing which was denied by appellee in an order dated September 4, 1981. Appellant then petitioned the vice-chairman of the Industrial Commission for a "personal review." This petition was treated as an application for reconsideration and was denied.
Appellant then filed this action in mandamus in the court of appeals requesting that court issue a writ to direct appellee to vacate its order granting claimant an additional award, and to find that claimant's injuries were not the result of any specific safety violation. In the alternative appellant requested a writ directing appellee to grant a rehearing on the merits of claimant's application for an additional award. The court of appeals denied appellant's requests.
The cause is now before this court upon an appeal as a matter of right.
Buckingham, Doolittle Burroughs and Timothy C. Campbell, for appellant.
Anthony J. Celebrezze, Jr., attorney general, Lee M. Smith and Douglas M. Kennedy, for appellee.
The question before this court is whether there is any evidence in the record to support appellee's finding that "* * * claimant's injury was the result of employer's failure to provide sufficient guards for the two-phase process during the entire operating cycle of the machine, as required by IC-5-08.03(A) * * *." (Emphasis sic.)
IC-5-08.03(A)(1) stated:
"Every power press in use shall be constructed, or shall be guarded to prevent the hands or fingers of the operator from entering the danger zone during the operating cycle."
Additionally, IC-5-08.03(B)(1)(d) specifically provided that the Pull and Restraint or Hold-Back Guard, of the type used on appellant's machine, was acceptable for guarding power presses. These specific safety requirements were enacted to "provide reasonable safety for life, limb and health of employees." IC-5-01.01. Accordingly, in State, ex rel. M.T.D. Products, v. Stebbins (1975), 43 Ohio St.2d 114 [72 O.O.2d 63], this court found that the safety requirements do not purport to impose absolute liability for an additional award. The M.T.D. court at 118 stated:
"* * * The regulation does not forewarn the employer that, in addition to providing a safety device, the safety device must also be completely failsafe. * * *"
In the instant case there appears to be no evidence to suggest that the Hold-Back Guard used by appellant was ineffective while the press was operating throughout its entire cycle in a normal fashion. To the contrary, within a month after the accident, an investigation by the U.S. Department of Labor's Occupational Safety and Health Administration revealed "no violations of existing or effective [safety] standards." In fact, the evidence before this court indicates the only time the guards failed to operate was when the press was activated manually by a person other than the operator in an attempt to correct an unrelated problem. IC-5-08.03(A), in conjunction with M.T.D., does not require that a power press operator's hands be guarded from ever entering the danger zone. Rather, it is only required that an operator's hands be guarded from entering the danger zone "during the [machine's] operating cycle." Since the evidence before this court supports the conclusion that claimant's injury did not occur during the operating cycle of the power press, and since we discern no evidence indicating that the guards were ineffective during the operating cycle of the power press, appellee's conclusion that appellant violated IC-5-08.03(A) is an abuse of discretion and can not stand.
We must now determine the appropriate remedy for appellee's abuse of discretion. This court was required to make a similar determination in State, ex rel. Cox, v. Indus. Comm. (1981), 67 Ohio St.2d 235 [23 O.O.3d 147]. In that case the court held at paragraph three of the syllabus:
"To be a proper order of the Industrial Commission, entered pursuant to R.C. 4121.06(A), the record must show that a majority of the commission could reasonably have based their approval and confirmation of the staff officer's order upon evidentiary matters within the record."
The Cox court found that since there was an absence of evidence in the record to support the hearing officer's decision, it was an abuse of discretion for the commission to enter an order in support of that decision, and a rehearing to clarify the evidence was necessary.
In the instant case there is an absence of evidence in the record to support the hearing officer's findings (1) that the guards failed to operate during the entire operating cycle of the machine and, more specifically, (2) that there was a manual phase of operation of the machine during which the guards failed to operate. Therefore, in accordance with Cox, a rehearing is necessary to adduce any and all evidence necessary to establish whether there has been a violation of a specific safety requirement.
Accordingly, we reverse the judgment of the court of appeals and order that a writ of mandamus be issued, directing the Industrial Commission to grant appellant a rehearing on the merits of claimant's application for an additional award.
Judgment reversed and writ allowed.
CELEBREZZE, C.J., SWEENEY, LOCHER, HOLMES, C. BROWN, DOUGLAS and WRIGHT, JJ., concur.